Page 11 - 《摩擦学学报》2021年第1期
P. 11

8                                       摩   擦   学   学   报                                 第 41 卷

            析解，无需进行较为复杂的迭代计算，简化了求解过                                10.3969/j.issn.0254-0150.2018.09.003.
            程，有利于油膜厚度在线测量系统实时性与准确性的                            [10]  Lu Xiqun. The modeling and application of coupled dynamics and
                                                                   tribology  of  piston  assembly[D].  Harbin:  Harbin  Engineering
            提高.
                                                                   University, 2013(in Chinese) [卢熙群. 内燃机活塞组件动力学与
                c. 当h/λ趋于0.25时，反射系数相移Φ趋于0，微弱                       摩擦学耦合建模及应用研究[D]. 哈尔滨: 哈尔滨工程大学, 2013].
            的噪声信号会引起较大的测量误差，油膜实际厚度越                            [11]  Wang  Naikun.  A  performance  research  on  lubrication  of  the  low
            大，其测量厚度随频率的波动程度越大. 使用单一中                               speed  diesel  engine  piston  ring  pack  considering  lubricating  oil
                                                                   supply[D]. Harbin: Harbin Engineering University, 2017(in Chinese)
            心频率计算油膜厚度可减小噪声信号产生的影响，进
                                                                   [王乃昆. 考虑滑油供给的低速柴油机活塞环组润滑性能研究[D].
            而提高油膜厚度测量结果的准确性.
                                                                   哈尔滨: 哈尔滨工程大学, 2017].
            参 考 文 献                                            [12]  Liu  Guangsheng.  Research  on  the  lubricant  oil  transportation  and
                                                                   lubrication  between  the  piston  assembly  and  the  cylinder  liner  of
            [  1  ]  Ba Lin. Research on lubrication of piston assembly and piston top
                                                                   internal  combustion  engines[D]  Hefei:  Hefei  University  of
                 fatigue  failure  under  lubrication  conditions[D].  Tianjin:  Tianjin
                                                                   Technology, 2018(in Chinese) [刘广胜. 内燃机活塞组件-缸套摩擦
                 University, 2014(in Chinese) [巴林. 活塞组润滑及润滑边界条件
                                                                   副润滑油输送和润滑研究[D]. 合肥: 合肥工业大学, 2018].
                 下活塞顶疲劳失效研究[D]. 天津: 天津大学, 2014].
                                                               [13]  Ma Xuan. Study on the effect of surface texture parameter on the
            [  2  ]  T B Lane J, R Hughes. A study of the oil-film formation in gears by
                                                                   lubrication   performance   of   piston/cylinder   interface   and
                 electrical  resistance  measurements[J].  British  Journal  of  Applied
                                                                   optimization  method[D].  Harbin:  Harbin  Engineering  University,
                 Physics, 1952, 3(10): 315–318. doi: 10.1088/0508-3443/3/10/305.
                                                                   2018 (in Chinese) [马旋. 表面织构参数对活塞/缸套摩擦副润滑行
            [  3  ]  Ziqiang  Cui,  Chengyi  Yang,  Benyuan  Sun,  et  al.  Liquid  film
                                                                   为的影响及优化方法研究[D]. 哈尔滨: 哈尔滨工程大学, 2018].
                 thickness  estimation  using  electrical  capacitance  tomography[J].
                                                               [14]  Lu  Xingchen.  Investigation  into  the  dynamic  lubrication  modeling
                 Measurement Science Review, 2014, 14(1): 8–15. doi: 10.2478/msr-
                                                                   and  friction  measuring  between  the  piston  and  cylinder  liner[D].
                 2014-0002.                                        Taiyuan: Taiyuan University of Technology, 2018(in Chinese) [鹿星
            [  4  ]  Huang Ping, Luo Jianbin, Zou Qian, et al. NGY-2 interferometer for  晨. 活塞-缸套动态润滑建模及摩擦测量研究[D]. 太原: 太原理工
                 nanometer  lubrication  film  thickness  measurement[J].  Tribology,
                                                                   大学, 2018].
                 1994, 14(2): 175–179 (in Chinese) [黄平, 雒建斌, 邹茜, 等. NGY-
                                                               [15]  T. Reddyhoff, S Kasolang, R S Dwyer-Joyce, et al The phase shift of
                 2型 纳 米 级 润 滑 膜 厚 度 测 量 仪 [J].  摩 擦 学 学 报 ,  1994,  14(2):  an  ultrasonic  pulse  at  an  oil  layer  and  determination  of  film
                 175–179].
                                                                   thickness[J]. Proceedings of the Institution of Mechanical Engineers.
            [  5  ]  Ma  Chong,  Guo  Feng,  Fu  Zhongxue,  et  al.  Measurement  of  Part  J:  Journal  of  Engineering  Tribology,  2005,  219(6):  387–400.
                 lubricating  oil  film  thickness  in  conformal  contacts[J].  Tribology,  doi: 10.1243/135065005X34044.
                 2010, 30(4): 419–424 (in Chinese) [马冲, 郭峰, 付忠学, 等. 微型滑  [16]  Pan Dou, Tonghai Wu, Zhaopeng Luo. Wide range measurement of
                 块 面 接 触 润 滑 油 膜 测 量 系 统 [J].  摩 擦 学 学 报 ,  2010,  30(4):  lubricant  film  thickness  based  on  ultrasonic  reflection  coefficient
                 419–424].                                         phase spectrum[J]. Journal of Tribology, 2019, 141(3): 031702. doi:
            [  6  ]  R  S  Dwyer-Joyce,  B  W  Drinkwater,  C  J  Donohoe  J.  The  10.1115/1.4041511.
                 measurement  of  lubricant  film  thickness  using  ultrasound[J].  [17]  Tom Pialucha, Peter Cawley. The detection of thin embedded layers
                 Proceedings:  Mathematical,  Physical  and  Engineering  Sciences,  using  normal  incidence  ultrasound[J].  Ultrasonics,  1994,  32(6):
                 2003, 459(2032): 957–976. doi: 10.1098/rspa.2002.1018.  431–440. doi: 10.1016/0041-624X(94)90062-0.
            [  7  ]  Shi  Yong,  Qi  Songbo,  Zhao  Jianhui,  et  al.  Error  analysis  of  [18]  A Hunter, R Dwyer-Joyce, P Harper. Calibration and validation of
                 ultrasonic method for measurement of oil film thickness[J]. Journal  ultrasonic  reflection  methods  for  thin-film  measurement  in
                 of  Harbin  Engineering  University,  2019,  40(3):  586–592  tribology[J].  Measurement  Science  and  Technology,  2012,  23(10):
                 (in Chinese) [石勇, 齐松博, 赵建辉, 等. 超声波测量油膜厚度方法        105605. doi: 10.1088/0957-0233/23/10/105605.
                 误差分析[J]. 哈尔滨工程大学学报, 2019, 40(3): 586–592].    [19]  Tattersall  H  G.  The  ultrasonic  pulse-echo  technique  as  applied  to
            [  8  ]  Li  Xiang.  Research  on  ultrasonic  measurement  system  of  oil  film  adhesion  testing[J].  Journal  of  Physics  D:  Applied  Physics,  1973,
                 thickness  based  on  AlN  piezoelectric  film[D].  Nanjing:  Nanjing  6(7): 819–832.
                 University of Aeronautics and Astronautics, 2018(in Chinese) [李响.  [20]  J  Zhang,  B  W  Drinkwater,  R  S  Dwyer-Joyce.  Calibration  of  the
                 基于AlN压电薄膜的超声油膜厚度测量系统关键技术研究[D]. 南                  ultrasonic  lubricant-film  thickness  measurement  technique[J].
                 京: 南京航空航天大学, 2018].                               Measurement  Science  and  Technology,  2005,  16(9):  1784–1791.
            [  9  ]  Li  Xiang,  Ma  Xizhi,  Zhang  Bugao.  Theory  and  numerical  doi: 10.1088/0957-0233/16/9/010.
                 calculation  of  acoustic  reflection  coefficient  for  oil  film  thickness  [21]  T Reddyhoff, R S Dwyer-Joyce, J Zhang, et al. Auto-calibration of
                 measurement[J].  Lubrication  Engineering,  2018,  43(9):  13–18,  27  ultrasonic  lubricant  film  thickness  measurements[J].  Measurement
                 (in Chinese) [李响, 马希直, 张步高. 油膜厚度超声测量声反射系          Science and Technology, 2007, 19(4): 045402. doi: 10.1088/0957-
                 数理论及数值计算[J]. 润滑与密封, 2018, 43(9): 13–18, 27]. doi:  0233/19/4/045402.
   6   7   8   9   10   11   12   13   14   15   16